Parts Depot HEATING
Printer Friendly Version Name * Response Email * Work Order Contractor ID Code Checking the Indoor Blower Section Indoor AHU / Furnace Make* Indoor AHU / Furnace Model* Evaporator Drain Line and Trap UnknownOKRemoved & Cleared DrainDrain Trap not removeableBlow clear flexable drain lineDrain Trap should be addedTest Condensate Pump OKCondensate Pump failed Indoor Blower Direct Drive / Belt Drive Direct DriveBelt DriveUnknown Check for Lubercation ports on motor No Access to motorNo oil portsOK-LubercatedOil Every 5 YearsUnkown Motor Bearings UnknownOKOk-LubricatedTightNoisyNew bearing installedBearing required Blower Bearings UnknownDirect Drive FanOKOk-LubercatedTightNoisyBearing RequiredNew Bearings installedNA Motor Pulley UnknownOKWorn SheavesUnbalancedLooseReplacedNewRequriedNA Blower Pulley UnknownOkWorn SheavesUnbalancedLooseReplacedNewRequiredNA Fan Belt UnknownOKNo BeltWornDriedCrackedRecently replacedNew belt required Belt Adjust to minimum tension UnkownOKDirect drive fanBelt is too bigBelt is too smallAdjusted tensionFan belt brokenUnknownNA Humidifer Bypass Damper No HumidiferDamper OpenDamper ClosedNo Damper Air filter Installed New FilterFitler recently replacedNo Access to FilterNo Filter RackUnkownNew filters required Suction Line Pipe Insulation UnknownOKPartially MissingUninsulatedInsulation required Comments: Filter and Belt Size Parts Required Actions Taken Checking the Outdoor Equipment Outdoor Unit Make Outdoor Unit Model Condenser coil condition CleanDustyDirtyPartially PluggedCompletely Plugged Outdoor Unit Casing Good ConditonPartially rustedVery rustedMissing Panels Is the area around the condenser clear YesPartially BlockedFully Blocked Clear area above the condenser UknownOpen20 feet10 feet5 feetLess than 3 feet Compressor Contactor UnknownOKContacts PittedBurn Marks on PointsContacts MeltedContactor StickyRequired Condenser Fan Motor Bearing UnknownOKTightNoisy WornRequired Condenser Fan Blade OKBentDamagedLooseReplacedRequired Outdoor Service Disconnect YesNoUnknown Comments Run the AC for 5 minutes and take the following temperature readings Temperature Reading °C or °F °F°C Supply Air Temperature Return Air Temperature Suction Line Temperature Outdoor Condenser Discharge Air Temperature Outdoor Air Temperature House Average Air Temperature Condensate Draining UnknownDrainingDryLeaking Comments	Heating Categories BOILERS: Controls Pumps Electric Zone Valves Pneumatic Zone Valve Air-Vents/Purgers Expansion Tank Vent Damper Thermostat GAS FURNACE: Thermocouple Controls Ignition Controller Gas Burners Motors Hot Surface Ignitors Gas Burners Blowers Thermostat Draft Inducers Valves HEAT PUMP: Controls Motors Thermostat OIL FURNACE: Pumps Controls Motors Oil Burners Tanks Thermostat Nozzles Motors Transformers Flame Relays Electrodes Barometric Damper Keyword searches work best with single words Part number search only need the first 3 or 4 characters More Information Change of Season Spring and fall are a challenge for your equipment to maintain comfort in the building Need help NOW!!! Our experienced technicians have over 20+ years in the field servings Cracked Heat Exchanger This is one I always hated telling the customer, "You have a cracked heat exchanger and your furnace has to be replaced,...Today." My Furnace burner cycles on and off There two things that normally cause burner short cycling Oil Burner Flame Failure Oil burners will shut down and require a manual reset. Residential boiler maintenace September is the time to get your boiler ready for the winter.
Home | About Us | Ask the Oracle | Parts | Service Tip | Links For questions about the content of this site, contact support@hvacoracle.com Site powered and maintained with Pagebuilder Copyright © All Rights Reserved 2004