Parts Depot HEATING
Online Version Name * Response E-mail* Work Order Contractor ID Code Checking the Indoor Blower Section Indoor AHU / Furnace Make* Indoor AHU / Furnace Model* Indoor Blower Direct Drive / Belt Drive Direct Drive Belt DriveUnknown Check for Lubrication ports on motor No Access to motorNo oil portsOK-LubricatedOil Every 5 YearsUnkown Motor Bearings UnknownOKOk-LubricatedTightNoisyNew bearing installedBearing required Blower Bearings UnknownDirect Drive FanOKOk-LubricatedTightNoisyBearing RequiredNew Bearings installedNA Motor Pulley UnknownOKWorn SheavesUnbalancedLooseReplacedNewRequriedNA Blower Pulley UnknownOkWorn SheavesUnbalancedLooseReplacedNewRequiredNA Fan Belt UnknownOKNo BeltWornDriedCrackedRecently replacedNew belt required Belt Adjust to minimum tension UnkownOKDirect drive fanBelt is too bigBelt is too smallAdjusted tensionFan belt brokenUnknownNA Humidified Bypass Damper No HumidiferDamper OpenDamper ClosedNo Damper Air filter Installed New FilterFitler recently replacedNo Access to FilterNo Filter RackUnkownNew filters required Suction/Big Line Pipe Insulation UnknownOKPartially MissingUninsulatedInsulation required Comments: Filter and Belt Size Parts Required Actions Taken Checking the Outdoor Equipment Outdoor Unit Make Outdoor Unit Model Outdoor coil condition CleanDustyDirtyPartially PluggedCompletely Plugged Outdoor Unit Casing Good ConditonPartially rustedVery rustedMissing Panels Is the area around clear YesPartially BlockedFully Blocked Clear area above UknownOpen20 feet10 feet5 feetLess than 3 feet Compressor Contactor UnknownOKContacts PittedBurn Marks on PointsContacts MeltedContactor StickyRequired Outdoor Fan Motor Bearing UnknownOKTightNoisy WornRequired Outdoor Fan Blade OKBentDamagedLooseReplacedRequired Outdoor Service Disconnect YesNoUnknown Comments Heat Pump Defrost Cycle Defrost Type Initiation UnknownTimeTemperaturePressureTime/TimeperatureTime/PressureOther Defrost Cycle Time Unknown30 Minutes60 Minutes90 Minutes120 Minutes120+ MinutesVariableOther Defrost Termination UnknownTimeTemperatureCoil PressureAir PressureTime/TemperatureTime/Pressure Back Up Heat Time NoneUnknownNatural GasPropaneOilElectric Radiant Back Heat Test No Back UpOKNot TestedDisabledUnknownOther Coil completely clear of ice after defrost cycle Clear75% Clear50 % Clear25 % ClearIce CoveredUnknown Outdoor fan discharge air pressure just before defrost initiations compared to max. air flow. Not Done100%75%50%25%10%No Air FlowUnknown Air flow right after defrost to max. air flow. Not Done100 %75 %50 % 25 %10 %No Air Flow Heat Pump Defrost Comments Run the Heat Pump in Heating Mode for 5 minutes and take the following temperature readings Temperature Reading °C or °F °F°C Supply Air Temperature Return Air Temperature Outdoor Fan Discharge Air Temperature Outdoor Air Temperature House Average Air Temperature Comments	BOILERS: BOILERS: Controls Pumps Electric Zone Valves Pneumatic Zone Valve Air-Vents/Purgers Expansion Tank Vent Damper Thermostat GAS FURNACE: Thermocouple Controls Ignition Controller Gas Burners Motors Hot Surface Ignitors Gas Burners Blowers Thermostat Draft Inducers Valves HEAT PUMP: Controls Motors Thermostat OIL FURNACE: Pumps Controls Motors Oil Burners Tanks Thermostat Nozzles Motors Transformers Flame Relays Electrodes Barometric Damper Keyword searches work best with single words Part number search only need the first 3 or 4 characters Change of Season Spring and fall are a challenge for your equipment to maintain comfort in the building Need help NOW!!! Our experienced technicians have over 20+ years in the field servings Cracked Heat Exchanger This is one I always hated telling the customer, "You have a cracked heat exchanger and your furnace has to be replaced,...Today." My Furnace burner cycles on and off There two things that normally cause burner short cycling Oil Burner Flame Failure Oil burners will shut down and require a manual reset. Residential boiler maintenace September is the time to get your boiler ready for the winter.
Home | About Us | Ask the Oracle | Parts | Service Tip | Links For questions about the content of this site, contact support@hvacoracle.com Site powered and maintained with Pagebuilder Copyright © All Rights Reserved 2004